Monthly Recall Report

Car Recall Report: December 2023

41 recalls · 6,570,725 vehicles

✓ Reviewed by Jacob Shayesteh, Esq.·Updated October 2026

Recalls

6,570,725

Vehicles covered

Do not drive / park outside

43%

Highest repeat-problem share

Mercedes-Benz

Most recalls

In December 2023, manufacturers reported 41 recalls on 2021 and newer cars, SUVs and pickups, covering 6,570,725 vehicles. 1 carried a do-not-drive or park-outside warning. Among recalls with enough owner complaints to measure, the highest share of repeat-problem reports since the recall was 43% (2023 Mercedes-Benz GLC 300 Engine Fastener Recall (23V878)).

Biggest recalls

What were the biggest car recalls of December 2023?

2021-2023 Honda Accord Fuel Pump Recall (23V858) Repeat recall
December 18, 2023 · 2,490,460 vehicles
Vehicles: 2021-2023 Honda Accord; 2021 Honda Civic; 2021-2023 Honda CR-V; 2023 Honda HR-V; 2022 Honda Insight; 2021-2023 Honda Odyssey; 2021 Honda Passport; 2021 Honda Pilot
The fuel pump inside the fuel tank may fail.
Risk: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Fix: Dealers will replace the fuel pump module, free of charge.
2021-2023 Tesla Model S Driver Monitoring Software Recall (23V838)
December 12, 2023 · 2,031,220 vehicles
Vehicles: 2021-2023 Tesla Model 3; 2021-2023 Tesla Model S; 2021-2023 Tesla Model X; 2021-2023 Tesla Model Y
In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Risk: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Fix: Tesla will release an over-the-air (OTA) software update, free of charge.
2021 Toyota Avalon Occupant Classification Recall (23V865)
December 20, 2023 · 999,901 vehicles
Vehicles: 2021 Lexus ES; 2021-2022 Lexus ES Hybrid; 2021 Lexus RX; 2021 Lexus RX Hybrid; 2021 Toyota Avalon; 2021 Toyota Avalon Hybrid; 2021-2022 Toyota Camry; 2021-2022 Toyota Camry Hybrid; 2021 Toyota Corolla; 2021 Toyota Highlander; 2021 Toyota Highlander Hybrid; 2021 Toyota RAV4; 2021 Toyota RAV4 Hybrid; 2021 Toyota Sienna Hybrid
A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Risk: An air bag that does not deploy during a crash increases the risk of injury.
Fix: Dealers will inspect and replace the sensor as necessary, free of charge.
2022-2024 Ford Maverick Lighting Bulbs Recall (23V848)
December 15, 2023 · 189,814 vehicles
Vehicles: 2022-2024 Ford Maverick
In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly.
Risk: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.
Fix: Dealers will update the body control module software, free of charge.
2021-2022 Ford Ecosport Engine Pump Recall (23V905)
December 22, 2023 · 139,730 vehicles
Vehicles: 2021-2022 Ford Ecosport
The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.
Risk: A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.
Fix: Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge.
2022-2023 Tesla Model S Electrical Software Recall (23V862) Repeat recall
December 19, 2023 · 120,423 vehicles
Vehicles: 2022-2023 Tesla Model S; 2022-2023 Tesla Model X
The cabin doors can be unlocked during a crash.
Risk: An unlocked door may unlatch and open during a crash, increasing the risk of injury.
Fix: Tesla has released an over-the-air (OTA) software update, free of charge.
2021-2023 Ford F-150 Axle Hubs Recall (23V896)
December 22, 2023 · 112,965 vehicles
Vehicles: 2021-2023 Ford F-150
75-inch heavy duty axle with a 3/4 float axle design.
Risk: Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.
Fix: Dealers will replace the left and right rear axle shaft assemblies, free of charge.
2021-2022 Honda CR-V Hybrid Battery Cable Recall (23V844)
December 13, 2023 · 106,030 vehicles
Vehicles: 2021-2022 Honda CR-V Hybrid
The 12-Volt battery cable routed outside of the body frame is missing a fuse on the power circuit, which can allow the battery cable to short circuit or overheat during a crash.
Risk: An overheated battery cable or short circuit can increase the risk of a fire or injury in a crash.
Fix: Dealers will replace the battery cable, free of charge.
2022-2024 Audi RS E-Tron GT Electrical Onboard Recall (23V842)
December 13, 2023 · 93,196 vehicles
Vehicles: 2021-2022 Audi A7; 2021 Audi A8; 2021-2024 Audi E-Tron; 2022-2024 Audi E-Tron GT; 2022-2024 Audi Q4 E-Tron; 2021-2024 Audi Q5; 2022-2024 Audi RS E-Tron GT
When using the industrial 220V/240V plug at the 100% charge setting, some home power outlets may be incapable of handling the electrical current required to utilize the compact charging system, causing the outlet or charging cable to overheat.
Risk: An overheated outlet or charging cable can increase the risk of a fire.
Fix: Owners are advised not to use the 220V/240V compact/portable charging cable and only use the 110V home charging cable or public charging stations.
2021-2023 Mercedes-Benz AMG E53 Fuel Pump Recall (23V880) Repeat recall
December 21, 2023 · 79,676 vehicles
Vehicles: 2023 Mercedes-Benz AMG C43; 2021-2023 Mercedes-Benz AMG E53; 2021-2023 Mercedes-Benz AMG E63; 2022-2023 Mercedes-Benz AMG G63; 2023 Mercedes-Benz AMG GLC43; 2022 Mercedes-Benz AMG GLE53; 2023-2024 Mercedes-Benz AMG GLE53 4MATIC+; 2022-2024 Mercedes-Benz AMG GLE63; 2022 Mercedes-Benz AMG GLS63; 2023 Mercedes-Benz AMG GLS63 4MATIC+; 2021-2023 Mercedes-Benz AMG GT43; 2022-2023 Mercedes-Benz AMG GT53; 2023 Mercedes-Benz AMG GT63; 2023 Mercedes-Benz AMG SL43; 2022-2023 Mercedes-Benz AMG SL55; 2022-2023 Mercedes-Benz AMG SL63; 2022-2024 Mercedes-Benz C 300; 2022-2023 Mercedes-Benz E 350; 2022-2023 Mercedes-Benz E 450; 2022-2023 Mercedes-Benz G 550; 2023 Mercedes-Benz GLC 300; 2021-2023 Mercedes-Benz GLE 350; 2022-2024 Mercedes-Benz GLE 450; 2022-2023 Mercedes-Benz GLE 580 4MATIC; 2022-2023 Mercedes-Benz GLS 450 4MATIC; 2022-2023 Mercedes-Benz GLS 580 4MATIC; 2022-2023 Mercedes-Benz S 500; 2022-2023 Mercedes-Benz S 580
Please refer to MBUSA's recall report for specific vehicle details.
Risk: A loss of drive power can increase the risk of a crash.
Fix: Dealers will replace the fuel pump, free of charge.

Safety warnings

Which December 2023 recalls said do not drive or park outside?

2022-2023 Mercedes-Benz AMG G63 Differential Recall (23V851) Do not driveRepeat recall
December 15, 2023 · 590 vehicles
Vehicles: 2022-2023 Mercedes-Benz AMG G63
The rear axle differential housing may develop cracks, possibly resulting in oil leaking onto the roadway or axle failure.
Risk: Oil leaking onto the roadway may cause a road hazard for following traffic. Rear axle failure can result in a sudden loss of handling or drive power. Either of these conditions can increase the risk of a crash.
Fix: Owners are advised not to drive their vehicles until the repair has been performed.

Our analysis

Which December 2023 recalls are owners saying did not fix the problem?

For each recall from this month with at least 5 NHTSA complaints about the same part filed since the recall, this table shows how many describe the problem happening more than once or coming back after a repair attempt. Complaints are unverified owner reports; automated text matching can miss or misread some.

Recall	Complaints since recall	Repeat-problem reports
2023 Mercedes-Benz GLC 300 Engine Fastener Recall (23V878)	7	3 (43%)
2022-2024 Ford Maverick Lighting Bulbs Recall (23V848)	9	3 (33%)
2023 Toyota Supra Transmission Control Module Recall (23V821)	6	2 (33%)
2024 Nissan Altima Rack and Pinion Recall (23V882)	5	1 (20%)
2022-2024 Audi RS E-Tron GT Electrical Onboard Recall (23V842)	106	20 (19%)
2021-2022 Audi E-Tron Electrical Management Software Recall (23V867)	33	6 (18%)
2021-2023 Mercedes-Benz AMG E53 Fuel Pump Recall (23V880)	35	5 (14%)
2024 Hyundai Kona Battery Cable Recall (23V901)	28	4 (14%)
2021-2023 Porsche Taycan High-Voltage Battery Recall (23V840)	36	5 (14%)
2021-2023 Tesla Model S Driver Monitoring Software Recall (23V838)	304	40 (13%)
2022-2023 Toyota Corolla Cross Instrument Cluster Recall (23V864)	23	3 (13%)
2021-2024 Porsche Cayenne E-Hybrid Electrical Onboard Recall (23V841)	42	5 (12%)
2021-2023 Ford F-150 Axle Hubs Recall (23V896)	495	58 (12%)
2021-2023 Honda Accord Fuel Pump Recall (23V858)	139	16 (12%)
2023-2024 Volkswagen ID.4 Body Recall (23V750)	27	3 (11%)

By the numbers

Which makes and parts had the most recalls in December 2023?

Make	Recalls
Mercedes-Benz	11
Ford	4
Porsche	3
Audi	3
Toyota	3
BMW	3
Honda	2
Chevrolet	2

Recall area	Recalls
Electrical System	8
Body, Doors and Seats	6
EV and Hybrid Battery	4
Fuel System	3
Driver Assistance	3
Engine	3
Lighting and Visibility	3
Air Bags	3

All recalls

Every recall reported in December 2023

Your rights

Can a recall or defect investigation make my car a lemon in California?

Not by itself. What matters is whether a covered defect keeps coming back or keeps your vehicle at the dealer, and a federal investigation or recall is strong evidence that the problem is real.

Under California’s Song-Beverly Consumer Warranty Act, a manufacturer that cannot fix a warranty defect that substantially impairs a vehicle’s use, value or safety within a reasonable number of attempts may have to repurchase or replace it (Civ. Code 1793.2(d)). Within the first 18 months or 18,000 miles, the law presumes a reasonable number of attempts after two repairs of a defect likely to cause death or serious injury, four repairs of the same defect, or more than 30 days out of service (Civ. Code 1793.22(b)).

An owner who prevails can recover reasonable attorney fees and costs from the manufacturer (Civ. Code 1794(d)). You pay nothing, win or lose. We are paid only if you win, and the manufacturer pays our fees, including in settlements. If a case is lost, our firm covers the costs.

From attorney Jacob Shayesteh

In our cases, a recall repair visit counts as a repair attempt, and it's strongest when the owner complained about the problem before the recall came out. A recall shows the defect is real and that enough owners reported it for the manufacturer to issue a fix.

The biggest mistake I see is waiting too long. The mileage offset starts at your first repair visit for the problem, so the sooner you take it in, the better. If the problem comes and goes, take it in when it happens. You can't go back to that date later.

If you get a recall notice, call a lemon law attorney right away. You may have taken the car in for the same problem before and forgotten, or there may be other recalls related to it.

Jacob Shayesteh, Esq. (SBN 362320), Founder and Managing Attorney. Quotes lightly edited for clarity. Prior results do not guarantee a similar outcome.

FAQ

Frequently asked questions

Does the recall fixing my car mean I have no case?

Not necessarily. Even if the recall repair fixed it, you may still have a case, and a car that's a year or more old can still qualify.

Do used cars qualify for California lemon law?

We take certified pre-owned, demo and dealer vehicles. Since the California Supreme Court's Rodriguez decision in 2024, ordinary used cars generally do not qualify.

How long does a recall lemon law case take?

Recall-related cases typically resolve in one to three months from your first call. Prior results do not guarantee a similar outcome.

What does a lemon law attorney cost?

You pay nothing, win or lose. We are paid only if you win, and the manufacturer pays our fees, including in settlements. If a case is lost, our firm covers the costs.

Sources

NHTSA investigation, recall and complaint data, accessed October 7, 2026
California Civil Code 1793.22

Reviewed by

Jacob Shayesteh, Esq., Founder and Managing Attorney of America’s Lemon Lawyer (Wynn Law Group, APC). Licensed by the State Bar of California, No. 362320. His practice focuses on California lemon law under the Song-Beverly Consumer Warranty Act.

State Bar of California license record · Avvo · Martindale-Hubbell · Lawyers.com · LinkedIn · Our attorneys

Attorney advertising. America’s Lemon Lawyer is a trade name of Wynn Law Group, APC. Responsible attorney: Jacob Shayesteh, Esq. (SBN 362320). This page reports public NHTSA data and is general information, not legal advice. Not affiliated with NHTSA or any vehicle manufacturer. Prior results do not guarantee a similar outcome.