Volvo XC40 Recalls (2021-2025)

What recalls does the Volvo XC40 have?

• 2021-2025 Volvo XC40 Backup Camera Software Recall (25V908) Repeat recall
  December 23, 2025 · 413,151 vehicles · Rearview Camera

  The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Risk: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.

  Fix: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge.

• 2025 Volvo EC40 Brake Recall (25V392)
  June 12, 2025 · 11,469 vehicles · Brakes

  In certain driving scenarios while coasting down a hill and using "B" mode or "One Pedal Drive," the vehicle may lose brake function.

  Risk: A loss of brake function increases the risk of a crash.

  Fix: Owners are advised not to use "B" Mode (for plug-in hybrid vehicles) or "One Pedal Drive" (for pure electric vehicles) until the repair has been completed.

• 2021-2025 Volvo XC40 Backup Camera Software Recall (25V282)
  May 8, 2025 · 413,151 vehicles · Rearview Camera

  The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Risk: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.

  Fix: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge.

• 2024 Volvo XC40 Electrical Software Recall (24V010)
  January 10, 2024 · 17,409 vehicles · Electrical System

  A diagnostic error in the Central Electronic Module (CEM) software may cause the left rear turn signal indicator to not function.

  Risk: A nonfunctioning exterior turn signal may not notify other drivers of a turning vehicle, increasing the risk of a crash.

  Fix: The CEM software will be updated by a dealer or through an over-the-air (OTA) update, free of charge.

• 2023 Volvo S60 Electrical Recall (23V188)
  March 22, 2023 · 393 vehicles · Electrical System

  A diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM).

  Risk: The false warning message could prevent the detection of an actual e-call system failure, which could delay an emergency response during a crash, increasing the risk of injury.

  Fix: Dealers will update the telematics and connectivity antenna module (TCAM) software, free of charge.

• 2023 Volvo S60 Brake Recall (23V012)
  January 19, 2023 · 27,457 vehicles · Brakes

  A diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control.

  Risk: A reduction in brake support functions can increase the risk of a crash.

  Fix: Volvo will release an over-the-air (OTA) BCM2 software update, free of charge.

• 2021 Volvo XC40 Engine Recall (21V881)
  November 12, 2021 · 4 vehicles · Engine

  A bolt that secures the cross-member bracket for the electrical motor in the engine compartment may be loose or missing.

  Risk: A loose or missing bolt may decrease the structural protection of the vehicle, increasing the risk of injury during a crash.

  Fix: Dealers will replace the cross-member bracket and install new bracket bolts, free of charge.

• 2021 Volvo XC40 Seat Belt Retractor Recall (21V682)
  September 1, 2021 · 19,149 vehicles · Seat Belts

  The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Risk: An unsecured child restraint system can increase the risk of injury during a crash.

  Fix: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge.

• 2021-2022 Volvo XC40 Electrical Management System Software Recall (21V109)
  February 24, 2021 · 2,278 vehicles · EV and Hybrid Battery

  The Battery Energy Control Module (BECM) microprocessor may reset and cause the high voltage system to disconnect.

  Risk: A disconnected high voltage system can cause a loss of drive power, increasing the risk of a crash.

  Fix: Volvo Car will notify owners, and dealers will install a software update, free of charge.

Which XC40 parts are recalled most?

Which XC40 model years have the most recalls?

How do I check my XC40 for open recalls?

Enter your 17-character VIN at NHTSA’s recall lookup. The lookup lists every open safety recall on that specific vehicle, so you will see which of the 9 Volvo XC40 campaigns above apply to you. You can also ask any authorized Volvo dealer to run the VIN. The VIN is on your registration card, your insurance card, and a plate at the lower driver-side corner of the windshield. Brand-new recalls can take a few days to show up, so check again if you received a letter.

What are XC40 owners reporting?

Owner complaints filed with NHTSA since 2020, by model year. Complaints are unverified owner reports, but the components that come up most often show where owners are having trouble.

Excerpts from owner complaints (unverified):

The 12-volt battery has failed on 5 occasions. Each time, I tried to unlock the vehicle after being away from it for a short period (e.g., 5-40 minutes). I had to use the manual key to unlock the vehicle, but the vehicle wouldn't start. I had the vehicle towed 4 times.

2021 VOLVO XC40 owner, Electrical System, NHTSA complaint 11634084

I was driving this car on Highway 99 on 7/11/2025. The dashboard flashed the message " Stop safely The vehicle will stop Propulsion system failure." I cut the lane and stopped my car on the Highway 99 shoulder. Just right, my car stopped on the Highway shoulder; it disabled itself and couldn't move at all.

2021 VOLVO XC40 owner, Fuel/Propulsion System, NHTSA complaint 11673958

Backup camera not working: Repeated get no backup camera image – just see a black screen with message "Camera unavailable" or "Camera temporarily unavailable". This happens more often than the camera works.

2022 VOLVO XC40 owner, Back Over Prevention: Sensing System: Camera, NHTSA complaint 11633941

Can a recall make your XC40 a lemon in California?

A recall alone does not make a Volvo XC40 a lemon. California's Song-Beverly Consumer Warranty Act looks at whether a warranty defect substantially impairs the vehicle's use, value or safety and was not fixed within a reasonable number of repair attempts (Civ. Code 1793.2(d)).

1 of the 9 recalls listed here follow an earlier campaign on the same component, which can mean a first fix did not work. 2 involve the engine, transmission or high-voltage battery, the kinds of repairs that often take several visits or weeks of downtime.

Within the first 18 months or 18,000 miles, California presumes the manufacturer had enough chances if the same defect was repaired two or more times when it is likely to cause death or serious injury, four or more times for any covered defect, or the vehicle was out of service more than 30 days in total (Civ. Code 1793.22(b)). Written notice to the manufacturer is required in some cases, and owners outside that window can still have a claim. An owner who prevails can recover reasonable attorney fees and costs from the manufacturer (Civ. Code 1794(d)). You pay nothing, win or lose. We are paid only if you win, and the manufacturer pays our fees, including in settlements. If a case is lost, our firm covers the costs.

What to keep: every repair order, the recall owner letters, your purchase or lease contract, and a log of dates, mileage and symptoms. Make sure every visit is written up, even when the dealer says it found nothing.

More Volvo XC40 lemon law pages

All Volvo recalls · 2021 Volvo XC40 lemon law · 2022 Volvo XC40 lemon law · 2023 Volvo XC40 lemon law · 2024 Volvo XC40 lemon law · 2025 Volvo XC40 lemon law

Other Volvo models with recalls

• C40BEV: 6 recalls
• EC40: 3 recalls
• EX30: 3 recalls
• EX30CC: 1 recall
• EX40: 3 recalls
• EX90: 3 recalls
• S60: 8 recalls
• S60PHEV: 1 recall
• S90: 6 recalls
• S90PHEV: 1 recall
• V60: 7 recalls
• V60CC: 7 recalls
• V60CCMHEV: 1 recall
• V60PHEV: 1 recall
• V90: 5 recalls
• V90CC: 5 recalls
• V90CCMHEV: 1 recall
• VN: 18 recalls
• Vah: 9 recalls
• Vhd: 18 recalls
• Vnl: 18 recalls
• Vnl (4): 19 recalls
• Vnr: 13 recalls
• Vnr (4): 9 recalls
• Vnre (electric): 7 recalls
• XC40: 9 recalls
• XC40BEV: 2 recalls
• XC60: 11 recalls
• XC60MHEV: 2 recalls
• XC60PHEV: 1 recall
• XC90: 11 recalls
• XC90MHEV: 1 recall
• XC90PHEV: 1 recall

Frequently asked questions about Volvo XC40 recalls