2022 Lincoln Aviator

Body & Structure

The 2022 Lincoln Aviator has generated 10 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “Rear door trim came loose and fell off while driving. Had the service department at the local dealership look at the missing trim on the rear of the car and they noticed multiple of the plastic clips holding the trim on the rear were broken and remained in the area where the trim was attached.” (NHTSA Complaint #11705135)

Backup Camera

The 2022 Lincoln Aviator has generated 9 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “The contact owns a 2022 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 50 MPH, the vehicle stalled. The contact was unable to pull over to the side of the road. It was unknown whether a warning light was illuminated. The vehicle failed to restart and was towed to the residence. The dealer was contacted and confirmed that the part for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 10,000.” (NHTSA Complaint #11690950)

Other Systems

The 2022 Lincoln Aviator has generated 4 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “Regarding safety recall notice 25S66/NHTSA recall 25V407 – we took our car to the local Lincoln dealer in Lubbock (Gene Messer Ford/Lincoln) in late November for the repair of the recall “C-Pillar Applique Delamination.” There was considerable wind/rattle noise coming from the passenger side, which is a component of the recall. After completing the recall we noticed the wind/rattle noise is still there and even slightly worse. We have contacted the service representative at Gene Messer Ford/Lincoln regarding this and have yet to receive a reply. We are reaching out to you for a solution to the noise problem. Any help is much appreciated! Thanks for your time, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)” (NHTSA Complaint #11713372)

Engine,Fuel/Propulsion System

Engine and cooling problems are among the most serious defects under California’s Song-Beverly Act. Owners of the 2022 Lincoln Aviator have reported issues including stalling, overheating, loss of power, rough idling, excessive oil consumption, and check engine lights that return after dealer repairs. With 4 NHTSA complaints on record, this defect pattern is well-documented. Owner reports include: “On July 25, 2025 my 2022 Lincoln Aviator Hybrid Grand Touring Edition stalled while driving on Interstate 25 in Colorado Springs. I lost partial control of the vehicle but was able to guide it onto the shoulder and allow it to coast to a stop. I had this vehicle towed to the dealership (where it was purchased new): Phil Long Lincoln, Motor City in Colorado Springs, Colorado. It has been there ever since (almost 5 months) and has not been repaired. The service department suspects that the current safety recall issued July 8, 2025 (NHTSA Recall number: 25V455) was the root cause. They claim they could find nothing in the logs but they cannot rule out this as a problem. This is a life threatening issue with this vehicle and I have also been without my car for almost 5 months with repair available or capable by the dealer or Lincoln. This a very unreasonable amount of time and has been an undue burden upon me. I have sought to get a vehicle buy back under both the Lemon Law and the duration of this safety recall and they have refused (Lincoln corporate and the dealership). Please help.” (NHTSA Complaint #11706296)

Electrical System,Engine,Fuel/Propulsion System

Engine and cooling problems are among the most serious defects under California’s Song-Beverly Act. Owners of the 2022 Lincoln Aviator have reported issues including stalling, overheating, loss of power, rough idling, excessive oil consumption, and check engine lights that return after dealer repairs. With 3 NHTSA complaints on record, this defect pattern is well-documented. Owner reports include: “high voltage alert and vehicle shuts down and unable to drive and car locks up Should be recall# 23s53 and NHTSA campaign # 23v-626 It has not been repaired yet and this is very frustrating has happened 4-5 times Last incident happened on 11/7/2025 inside of a car wash & had to get towed” (NHTSA Complaint #11698286)

Active NHTSA Recalls — 2022 Lincoln Aviator

The following 19 recalls have been issued for the 2022 Lincoln Aviator by the NHTSA or Lincoln. If your vehicle is affected, the manufacturer is required to provide a free remedy. Check your VIN at NHTSA.gov/recalls.

California Lemon Law — Song-Beverly Act

California’s Song-Beverly Consumer Warranty Act (Cal. Civ. Code §§ 1790–1795.8) is one of the strongest lemon laws in the United States. It protects buyers and lessees of new and certified pre-owned vehicles that develop substantial defects the manufacturer cannot repair after a reasonable number of attempts.

Under Cal. Civ. Code § 1793.22, a lemon law presumption is triggered when any of the following apply to your 2022 Lincoln Aviator:

• 4+ repair attempts for the same non-safety defect without resolution
• 2+ repair attempts for a defect likely to cause death or serious bodily injury
• 30+ calendar days out of service for warranty repairs (cumulative, not consecutive)

Once the presumption is triggered, the burden shifts to Lincoln to prove the vehicle is not a lemon. Under Cal. Civ. Code § 1794(d), Lincoln must pay your attorney’s fees if you prevail — meaning qualified representation costs you nothing out of pocket.

What You Can Recover

If your 2022 Lincoln Aviator qualifies as a lemon under California law, Lincoln may be legally required to:

• Repurchase your vehicle — Full refund of your down payment, all monthly payments, registration fees, and incidental costs (towing, rentals), minus a mileage offset for miles driven before the first repair attempt
• Replace your vehicle — Provide a new, comparable vehicle at no cost to you
• Pay your attorney’s fees — Under § 1794(d), Lincoln pays all legal fees if you prevail
• Civil penalty up to 2x damages — If Lincoln willfully violated the Act, courts may award double the actual damages

Steps to Protect Your 2022 Lincoln Aviator Claim

Step 1: Document every repair visit. Keep all repair orders, work orders, and dealer invoices. Each visit counts as a repair attempt, even if the dealer says nothing is wrong.

Step 2: Keep returning for repairs. You must give Lincoln a reasonable opportunity to fix the defect. Visit different authorized Lincoln dealers if needed and ask for written documentation of each visit.

Step 3: Contact a California lemon law attorney. Once you believe the threshold has been met — 4 attempts for non-safety defects, 2 for safety defects, or 30 days out of service — contact an attorney for a free case evaluation. Under § 1794(d), Lincoln pays your fees if you win.

Step 4: Send a demand letter. Your attorney will send Lincoln a formal demand letter. Most California lemon law cases resolve through negotiation without going to trial.

2022 Lincoln Aviator Lemon Law Questions

How many repair attempts qualify my 2022 Lincoln Aviator as a lemon?

Under Cal. Civ. Code § 1793.22, four or more repair attempts for the same non-safety defect, or two attempts for a safety-related defect, triggers the lemon law presumption. Additionally, 30 or more cumulative days out of service qualifies regardless of the number of repair attempts.

Does Lincoln pay my attorney fees?

Yes. Under Cal. Civ. Code § 1794(d), Lincoln is required to pay your reasonable attorney’s fees and court costs if you prevail in a lemon law claim. This means qualified lemon law representation is free to you if your case succeeds.

Can I file a lemon law claim without an active recall?

Yes. A recall is not required to file a lemon law claim. The Song-Beverly Act covers any substantial defect that impairs the use, value, or safety of the vehicle that the manufacturer cannot repair after a reasonable number of attempts. NHTSA complaints support the claim by establishing a pattern, but are not a prerequisite.

What is the time limit to file a lemon law claim for my 2022 Lincoln Aviator?

California lemon law claims are generally subject to a four-year statute of limitations from the date you discovered or should have discovered the defect. However, you must still be within the manufacturer’s original warranty period when the defect first appears. Contact an attorney promptly to preserve your rights.