2021 Volkswagen Tiguan

Engine

Engine and cooling problems are among the most serious defects under California’s Song-Beverly Act. Owners of the 2021 Volkswagen Tiguan have reported issues including stalling, overheating, loss of power, rough idling, excessive oil consumption, and check engine lights that return after dealer repairs. With 40 NHTSA complaints on record, this defect pattern is well-documented. Owner reports include: “After oil changes (always maintained at dealerships) it would require a quart of oil with in 2 days. Random starts will blow smoke out the rear. random sluggish behavior. Dealership confirmed PCV valve is causing a buildup in engine pressure which caused a premature oil pan gasket leak. Without full teardown cannot know full extent of damages caused. (which spills out of the bottom and towards tires…..) dealership and fellow Tiguan owners have all reported the same issue! with a repair cost of $1,000-8,000+. same with alot of other years as well.. The date below that i will list is for when the problem was fully confirmed (89k miles) but has always been an issue told its fine … really noticed it after (68k miles) when i purchased the vehicle. With how many people are dealing with this it is hard to understand how we dont see an open recall for them….. also dealer said pvc valves are on back order and have been. why should one replace with oem if they won’t acknowledge its a faulty part?” (NHTSA Complaint #11723365)

Other Systems

The 2021 Volkswagen Tiguan has generated 38 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “The overhead console has come disconnected inside of the vehicle. I am seeing countless comments and posts online, both on Volkswagen site as well as other automotive sites, that also report this same issue for Tiguan autos from the 2020 through 2022 years. My car is a 2021 VW Tiguan. I am calling the Perrysburg Auto Mall VW Dealership located in Perrysburg, OH to request full service and that this should be covered under the extended warranty that I have seen is a part of this automobile. I wanted to make sure I reported this incident to this governing board.” (NHTSA Complaint #11691623)

Body & Structure

The 2021 Volkswagen Tiguan has generated 12 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “The upper control panel housing failed. My safety was put at risk because while driving the panel randomly dropped from my ceiling, blocking my rear view mirror and surprising me. The vehicle has not been looked at by the anyone else other than myself. There are many documented cases online from people experiencing the same kind of situation. There were no warning lights or symptoms that this was going to happen.” (NHTSA Complaint #11670996)

Electrical System

Electrical system failures are notoriously difficult to diagnose and repair, which often results in multiple unsuccessful repair attempts — a key element of a lemon law claim. Reported issues for the 2021 Volkswagen Tiguan include infotainment malfunctions, battery drain, warning lights, power window failures, and intermittent starting problems. 10 NHTSA complaints have been filed for this category. Owner reports include: “The contact owns a 2021 Volkswagen Tiguan. The contact stated that while his wife was driving slowly in traffic, several unknown warning lights illuminated orange, and the speedometer and RPM went to zero. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that minutes later, the vehicle returned to function as intended. The contact’s wife stated that after several minutes, the lights and indicators returned to normal function. A short while later, the failure reoccurred, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle then returned to function as intended. The contact stated that on a separate occasion, the driver’s side door failed to open. While using the key fob, the doors failed to open. The contact’s wife tested the door, and the only door that opened was the rear passenger’s side door. The contact’s wife opened the driver’s side door manually. The vehicle then failed to start. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. Three hours later, when the contact arrived at the residence, the contact was able to start the vehicle, the doors opened as intended, and the contact was able to drive around the neighborhood. The manufacturer was not notified of the failure. The failure mileage was approximately 29,180.” (NHTSA Complaint #11715976)

Fuel System

Fuel and propulsion system defects can cause stalling, fuel leaks, or power loss — all substantial impairments of use and safety. The 2021 Volkswagen Tiguan has generated 10 NHTSA complaints for this defect category. Owner reports include: “My fuel system level indicator does not work properly when the tank is below 1/2 full, and the check engine light comes on. It does not correctly deplete, instead leaving me with no gas when it shows it still has gas available. This has left me stranded in various locations as my car runs out of gas, but doesn’t show me that until it is completely empty. Most recently, it was on a very busy road in the middle of traffic. The gas gauge went from 1/2 full to empty while I was driving. Upon taking it to the dealer, they said to replace the 1 sensor, which is a very small, simple piece, they have to replace the entire fuel system, which is over $5000 in repairs. My car is only 4 years old and only out of warranty by 6 months. Further research shows this is a common issue with the make and model of my car. Many seem to happen under warranty, but with the age my car is now, many of these warranties will expire, leaving owners to have to pay to fix this outrageous, costly repair.” (NHTSA Complaint #11706676)

Active NHTSA Recalls — 2021 Volkswagen Tiguan

The following 5 recalls have been issued for the 2021 Volkswagen Tiguan by the NHTSA or Volkswagen. If your vehicle is affected, the manufacturer is required to provide a free remedy. Check your VIN at NHTSA.gov/recalls.

California Lemon Law — Song-Beverly Act

California’s Song-Beverly Consumer Warranty Act (Cal. Civ. Code §§ 1790–1795.8) is one of the strongest lemon laws in the United States. It protects buyers and lessees of new and certified pre-owned vehicles that develop substantial defects the manufacturer cannot repair after a reasonable number of attempts.

Under Cal. Civ. Code § 1793.22, a lemon law presumption is triggered when any of the following apply to your 2021 Volkswagen Tiguan:

• 4+ repair attempts for the same non-safety defect without resolution
• 2+ repair attempts for a defect likely to cause death or serious bodily injury
• 30+ calendar days out of service for warranty repairs (cumulative, not consecutive)

Once the presumption is triggered, the burden shifts to Volkswagen to prove the vehicle is not a lemon. Under Cal. Civ. Code § 1794(d), Volkswagen must pay your attorney’s fees if you prevail — meaning qualified representation costs you nothing out of pocket.

What You Can Recover

If your 2021 Volkswagen Tiguan qualifies as a lemon under California law, Volkswagen may be legally required to:

• Repurchase your vehicle — Full refund of your down payment, all monthly payments, registration fees, and incidental costs (towing, rentals), minus a mileage offset for miles driven before the first repair attempt
• Replace your vehicle — Provide a new, comparable vehicle at no cost to you
• Pay your attorney’s fees — Under § 1794(d), Volkswagen pays all legal fees if you prevail
• Civil penalty up to 2x damages — If Volkswagen willfully violated the Act, courts may award double the actual damages

Steps to Protect Your 2021 Volkswagen Tiguan Claim

Step 1: Document every repair visit. Keep all repair orders, work orders, and dealer invoices. Each visit counts as a repair attempt, even if the dealer says nothing is wrong.

Step 2: Keep returning for repairs. You must give Volkswagen a reasonable opportunity to fix the defect. Visit different authorized Volkswagen dealers if needed and ask for written documentation of each visit.

Step 3: Contact a California lemon law attorney. Once you believe the threshold has been met — 4 attempts for non-safety defects, 2 for safety defects, or 30 days out of service — contact an attorney for a free case evaluation. Under § 1794(d), Volkswagen pays your fees if you win.

Step 4: Send a demand letter. Your attorney will send Volkswagen a formal demand letter. Most California lemon law cases resolve through negotiation without going to trial.

2021 Volkswagen Tiguan Lemon Law Questions

How many repair attempts qualify my 2021 Volkswagen Tiguan as a lemon?

Under Cal. Civ. Code § 1793.22, four or more repair attempts for the same non-safety defect, or two attempts for a safety-related defect, triggers the lemon law presumption. Additionally, 30 or more cumulative days out of service qualifies regardless of the number of repair attempts.

Does Volkswagen pay my attorney fees?

Yes. Under Cal. Civ. Code § 1794(d), Volkswagen is required to pay your reasonable attorney’s fees and court costs if you prevail in a lemon law claim. This means qualified lemon law representation is free to you if your case succeeds.

Can I file a lemon law claim without an active recall?

Yes. A recall is not required to file a lemon law claim. The Song-Beverly Act covers any substantial defect that impairs the use, value, or safety of the vehicle that the manufacturer cannot repair after a reasonable number of attempts. NHTSA complaints support the claim by establishing a pattern, but are not a prerequisite.

What is the time limit to file a lemon law claim for my 2021 Volkswagen Tiguan?

California lemon law claims are generally subject to a four-year statute of limitations from the date you discovered or should have discovered the defect. However, you must still be within the manufacturer’s original warranty period when the defect first appears. Contact an attorney promptly to preserve your rights.