2024 Tesla Cybertruck

Body & Structure

The 2024 Tesla Cybertruck has generated 28 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “The side sails at the rear of the vehicle, lateral to the bed, are only adhered by double sided tape and can fall off while driving, causing damage to others. This has happened 2 times to my vehicle, it would ah element 3, but we stopped 1 from flying off” (NHTSA Complaint #11721244)

Other Systems

The 2024 Tesla Cybertruck has generated 12 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “I am submitting this safety complaint as the vehicle owner of a Tesla that was involved in a collision on November 15, 2025. Although I am the policyholder and registered owner, I was not the driver at the time of the incident. My husband, [XXX] , was operating the vehicle, and Tesla Autopilot/FSD was engaged when the loss of control occurred. At the time of the incident, it was raining heavily, though visibility and road conditions were still within what Autopilot typically handles during normal operation. While driving under these conditions with Autopilot activated, the vehicle suddenly exhibited unexpected and erratic steering behavior, causing it to lose stability and veer out of control. The deviation happened rapidly and without sufficient warning or opportunity for my husband to intervene manually. The resulting collision appeared to be the result of an Autopilot system malfunction, not driver error. Key concerns include: Autopilot’s failure to maintain proper lane position Sudden abnormal steering input originating from the system Possible sensor, perception, or weather-related detection failure Lack of adequate warning or disengagement alert prior to the loss of control Tesla Insurance later determined the driver to be “principally at fault,” but this conclusion did not consider the possibility of Autopilot system failure under heavy rain conditions and does not reflect the sequence of events as experienced by the driver. As the vehicle owner, I am requesting that NHTSA review this incident as a potential safety defect involving Tesla’s Autopilot/FSD system. I am concerned that this malfunction—particularly under adverse weather—may also affect other Tesla owners and could indicate a broader systemic safety issue. I am willing to provide additional information, driver statements, documentation, or vehicle data upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)” (NHTSA Complaint #11702702)

Visibility/Wiper

The 2024 Tesla Cybertruck has generated 11 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “The adhesive that attaches the front windshield is separating from the front windshield also it appears the the actual windshield is delaminating. This is causing a hazzard to driving. Especially when the sun is coming right at the vehicle.” (NHTSA Complaint #11690617)

Electrical System

Electrical system failures are notoriously difficult to diagnose and repair, which often results in multiple unsuccessful repair attempts — a key element of a lemon law claim. Reported issues for the 2024 Tesla Cybertruck include infotainment malfunctions, battery drain, warning lights, power window failures, and intermittent starting problems. 7 NHTSA complaints have been filed for this category. Owner reports include: “PCS2_a094 AC Charging unavailable This warning creates a situation of not be able to charge at all. Requiring a tow. I’ve was stranded with no way to charge. Had to leave my wife and kids cause I didn’t have enough charge to get them and get the truck back to a service center and another vehicle to get them home. Truck only a year old and 37k miles. Multiple owners reporting the same issue at a cost of 7k to replace PCS unit. Fail around 30k miles and then screwed once it’s out of warranty.” (NHTSA Complaint #11724326)

Exterior Lighting

The 2024 Tesla Cybertruck has generated 6 NHTSA complaints for this defect category. If your vehicle has experienced recurring issues in this area that the dealer has been unable to repair after multiple attempts, you may have a qualifying lemon law claim under California’s Song-Beverly Consumer Warranty Act. Owner reports include: “Tesla sent me a Recall notice on the Lightbar, but in the notice, Tesla says it will not connect the lightbar to the electrical system and make the lightbar operable when Tesla repairs the defective lightbar. I paid $300.00 to have the original lightbar connected to the electrical system, and now, due to Tesla’s improper installation, I am going to have to pay to have the new lightbar connected as well. This is unfair, unjust, and allows Tesla to escape twice. This leaves a huge financial burden on consumers. Make Tesla repair and make the light bar operable, and return me to the position I was in before they improperly installed the lightbar.” (NHTSA Complaint #11722535)

Active NHTSA Recalls — 2024 Tesla Cybertruck

The following 10 recalls have been issued for the 2024 Tesla Cybertruck by the NHTSA or Tesla. If your vehicle is affected, the manufacturer is required to provide a free remedy. Check your VIN at NHTSA.gov/recalls.

California Lemon Law — Song-Beverly Act

California’s Song-Beverly Consumer Warranty Act (Cal. Civ. Code §§ 1790–1795.8) is one of the strongest lemon laws in the United States. It protects buyers and lessees of new and certified pre-owned vehicles that develop substantial defects the manufacturer cannot repair after a reasonable number of attempts.

Under Cal. Civ. Code § 1793.22, a lemon law presumption is triggered when any of the following apply to your 2024 Tesla Cybertruck:

• 4+ repair attempts for the same non-safety defect without resolution
• 2+ repair attempts for a defect likely to cause death or serious bodily injury
• 30+ calendar days out of service for warranty repairs (cumulative, not consecutive)

Once the presumption is triggered, the burden shifts to Tesla to prove the vehicle is not a lemon. Under Cal. Civ. Code § 1794(d), Tesla must pay your attorney’s fees if you prevail — meaning qualified representation costs you nothing out of pocket.

What You Can Recover

If your 2024 Tesla Cybertruck qualifies as a lemon under California law, Tesla may be legally required to:

• Repurchase your vehicle — Full refund of your down payment, all monthly payments, registration fees, and incidental costs (towing, rentals), minus a mileage offset for miles driven before the first repair attempt
• Replace your vehicle — Provide a new, comparable vehicle at no cost to you
• Pay your attorney’s fees — Under § 1794(d), Tesla pays all legal fees if you prevail
• Civil penalty up to 2x damages — If Tesla willfully violated the Act, courts may award double the actual damages

Steps to Protect Your 2024 Tesla Cybertruck Claim

Step 1: Document every repair visit. Keep all repair orders, work orders, and dealer invoices. Each visit counts as a repair attempt, even if the dealer says nothing is wrong.

Step 2: Keep returning for repairs. You must give Tesla a reasonable opportunity to fix the defect. Visit different authorized Tesla dealers if needed and ask for written documentation of each visit.

Step 3: Contact a California lemon law attorney. Once you believe the threshold has been met — 4 attempts for non-safety defects, 2 for safety defects, or 30 days out of service — contact an attorney for a free case evaluation. Under § 1794(d), Tesla pays your fees if you win.

Step 4: Send a demand letter. Your attorney will send Tesla a formal demand letter. Most California lemon law cases resolve through negotiation without going to trial.

2024 Tesla Cybertruck Lemon Law Questions

How many repair attempts qualify my 2024 Tesla Cybertruck as a lemon?

Under Cal. Civ. Code § 1793.22, four or more repair attempts for the same non-safety defect, or two attempts for a safety-related defect, triggers the lemon law presumption. Additionally, 30 or more cumulative days out of service qualifies regardless of the number of repair attempts.

Does Tesla pay my attorney fees?

Yes. Under Cal. Civ. Code § 1794(d), Tesla is required to pay your reasonable attorney’s fees and court costs if you prevail in a lemon law claim. This means qualified lemon law representation is free to you if your case succeeds.

Can I file a lemon law claim without an active recall?

Yes. A recall is not required to file a lemon law claim. The Song-Beverly Act covers any substantial defect that impairs the use, value, or safety of the vehicle that the manufacturer cannot repair after a reasonable number of attempts. NHTSA complaints support the claim by establishing a pattern, but are not a prerequisite.

What is the time limit to file a lemon law claim for my 2024 Tesla Cybertruck?

California lemon law claims are generally subject to a four-year statute of limitations from the date you discovered or should have discovered the defect. However, you must still be within the manufacturer’s original warranty period when the defect first appears. Contact an attorney promptly to preserve your rights.